Rex Zietsman wrote:
Hi all,
......
In my area we have a large number of dairy farms milking >500 cows. These
are sizeable operations and the manure they produce is worth pursuing.
Typically they all have slurry dams and they spread their manure from time
to time (much to our temporary dismay while the odour kills us!). The
question is: what is an economical way of producing gas? ......
Hello Rex
You seem to be in the classical situation of being too big for ad hoc solutions but too small for
automated low labour installations.
My suggestion, is there a way in which the dairy farms co-operate to run a
central biogas installation?
Perhaps each farm has a de-watering plant and transports the 'cake' only to be
digested in a dry
digestion type facility. On site the fluid faction can be treated in a simple
manner to produce
biogas(if desired) eg sequencing batch method (fill, react, decant on a daily
basis).
The digestate is valueable (probably worth the exercise by itself especially
for an organic farm)
note the fluid should also be used in conjunction, having the N component and (can't remember which) some
of the P or K component.
In my opinion, heating is the major factor, for installations not located in
the tropics. Recovered heat
from an engine is possibly the easiest heat source. However if you can keep the quantity of liquid down,
pre heating the influent (to make up for the heat loss from the digesting mass) seems to work alright.
My suggestion for on farm digesters ie centralised digester is not an option -- most of your efforts will
possibly have to be justifying the cost versus benefit, perhaps if you could figure a way for direct
burning (on farm)of the gas coupled with the fertiliser benefit, a simple trench covered with a membrane
might make an economic match.
I mentioned dry digestion. I think I have developed a methodology for digesting
grass. Basically,
grass and foodscraps are allowed to soften in a vessel and then are leached (flooded method) with
effluent from the digester. The leachate spends a day in another vessel where (I believe... hope I am
correct) simpler acids are formed and then input into the digester.
Perhaps cow manure'cake' can be adapted to this method.
The digester is fixed film. Urethane foam cubes as carriers in the intermediate
vessel.
kia ora
stev Rodda
_______________________________________________
Digestion mailing list
to Send a Message to the list, use the email address
[email protected]
to UNSUBSCRIBE or Change your List Settings use the web page
http://lists.bioenergylists.org/mailman/listinfo/digestion_lists.bioenergylists.org
for more information about digestion, see
Beginner's Guide to Biogas
http://www.adelaide.edu.au/biogas/
and the Biogas Wiki http://biogas.wikispaces.com/
