Technically, it is possible to salvage a considerable portion of the waste heat which is normally discarded by an I.C.Engine to assist in the production of methane from hot CO2 in the presence of biomass or any other hydro carbon, The extra input of energy to assist the reaction can be in the form of an electrical plasma which could be obtained from say a 100amp automotive alternator. There are other issues such as N2 removal from the fuel loop. This is the way it will go. Sabatier reaction >From Wikipedia, the free encyclopedia The Sabatier reaction or Sabatier process was discovered by the French chemist Paul Sabatier in the 1910s. It involves the reaction of hydrogen with carbon dioxide at elevated temperatures (optimally 300–400 °C) and pressures in the presence of a nickel catalyst to produce methane and water. Optionally, ruthenium on alumina (aluminum oxide) makes a more efficient catalyst. It is described by the following exothermic reaction: CO2 + 4 H2 + energy → CH4 + 2 H2O ∆H = −165.0 kJ/mol (some initial energy/heat is required to start the reaction) GFWHELL
In a message dated 5/14/2014 1:57:31 P.M. Eastern Daylight Time, [email protected] writes: Dear Art, yes I agree with you, that using methane from natural gas would make the process simpler and cheaper than using coal. Besides, using coal would also involve getting rid of ash. Perhaps, one can produce enough methane from agricultural and urban waste, which would make it a carbon neutral process. Yours A.D.Karve On Wed, May 14, 2014 at 12:37 PM, Art Krenzel <[email protected]> wrote: > Dr. Karve, > > Being able to technically generate hydrogen using incandescent carbon in a > water gas reaction does not make the process economically competitive. > Typically, the use of incandescent carbon is a batch, cyclic process which > produces pulses of gases which vary in purity over each cycle > > Compare the economics of using a batch feedstock which has a variable > composition to one which has a very pure, low cost feedstock (CH4) day in > and day out. As a process designer, you can readily see that even through > the chemistry works out to generate hydrogen using incandescent carbon, the > day to day practicality of operating a multistage process with such a > variable feedstock is much more difficult and more expensive. > > Art > > > > >> Date: Tue, 13 May 2014 06:34:07 +0530 >> From: [email protected] >> To: [email protected] > >> Subject: Re: [Gasification] Tennessee company - pyrolysis biochar + >> hydrogen ($1.75 per gallon diesel-equivalent?) >> >> Dear Art, >> I am not a chemist but I feel that we can also separate the hydrogen >> from water gas. India is the world's third largest producer of >> chemical fertilizers and I am quite sure that the Indian fertilizer >> producers also use natural gas as their source of hydrogen. India >> generates annually about 800 million tonnes of agricultural waste, >> which can serve as the source to produce charcoal. This charcoal would >> have the same amount of energy as all the petroleum that we import. >> We have developed charring kilns for charring light biomass into a >> powdery charcoal. currently we briquette it and use it as domestic >> fuel. We have also made water gas from our char and demonstrated its >> use as fuel. >> Yours >> A.D.Karve >> >> On Mon, May 12, 2014 at 10:46 AM, Greg Manning <[email protected]> wrote: >> > Art >> > >> > Thank you for the explanation, >> > >> > I knew they used natural gas, but had no idea of the process. >> > >> > Greg Manning >> > >> > >> > On Sun, May 11, 2014 at 9:28 PM, Art Krenzel <[email protected]> >> > wrote: >> >> >> >> Dr. Karve, >> >> >> >> The Haber Bosch Process is used to convert hydrogen from natural gas >> >> and >> >> nitrogen from air into ammonia. Yes, it is an energy intensive process. >> >> >> >> See: http://en.wikipedia.org/wiki/Haber_process >> >> >> >> This conversion is typically conducted at 15-25 MPa (2,200-3,600 psi) >> >> or >> >> 150-250 bar and between 300-550 °C (572-1,022 °F), as the gases are >> >> passed >> >> over four beds of catalyst, with cooling between each pass so as to >> >> maintain >> >> a reasonable equilibrium constant. On each pass only about 15% >> >> conversion >> >> occurs, but any unreacted gases are recycled, and eventually an overall >> >> conversion of 97% is achieved.[1] >> >> >> >> Art Krenzel >> >> >> >> >> >> >> >> >> >> > Date: Mon, 12 May 2014 07:29:51 +0530 >> >> > From: [email protected] >> >> > To: [email protected]; >> >> > [email protected] >> >> > Subject: Re: [Gasification] Tennessee company - pyrolysis biochar + >> >> > hydrogen ($1.75 per gallon diesel-equivalent?) >> >> >> >> > >> >> > Dear Greg, >> >> > the major component of natural gas is methane. How does the >> >> > fertilizer >> >> > industry separate out hydrogen from methane? The process must be >> >> > consuming a lot of energy. >> >> > Yours >> >> > A.D.Karve >> >> > >> >> > On Sun, May 11, 2014 at 9:02 AM, Anand Karve <[email protected]> >> >> > wrote: >> >> > > Dear List, >> >> > > Already in the first decade of the last century, Haber in Germany >> >> > > developed a process for making ammonia by combining nitrogen in the >> >> > > air with hydrogen. I was told that this process is used even today >> >> > > by >> >> > > fertilizer manufacturers. Where does the fertilizer industry get >> >> > > its >> >> > > hydrogen from? >> >> > > Yours >> >> > > A.D.Karve >> >> > > >> >> > > On Fri, May 9, 2014 at 8:59 PM, John Bonitz [email protected] >> >> > > [biochar-policy] <[email protected]> wrote: >> >> > >> >> >> > >> >> >> > >> Return of the Pyromaniax: Proton Power and its hydrous pyrolysis >> >> > >> process for >> >> > >> super low-cost hydrogen, by Jim Lane, May 8, 2014 >> >> > >> >> >> > >> >> >> > >> >> >> > >> http://www.biofuelsdigest.com/bdigest/2014/05/08/return-of-the-pyromaniax-proton-power-and-its-hydrous-pyrolysis-process-for-super-low-cost- hydrogen/ >> >> > >> >> >> > >> >> >> > >> >> >> > >> John Bonitz >> >> > >> Pittsboro, NC >> >> > >> >> >> > >> 919-360-2492 | LinkedIn >> >> > >> >> >> > >> ~~~~~~~~~~~~~ >> >> > >> >> >> > >> >> >> > >> _______________________________________________ >> >> > >> Gasification mailing list >> >> > >> >> >> > >> to Send a Message to the list, use the email address >> >> > >> [email protected] >> >> > >> >> >> > >> to UNSUBSCRIBE or Change your List Settings use the web page >> >> > >> >> >> > >> >> >> > >> http://lists.bioenergylists.org/mailman/listinfo/gasification_lists.bioenergylists.org >> >> > >> >> >> > >> for more Gasifiers, News and Information see our web site: >> >> > >> http://gasifiers.bioenergylists.org/ >> >> > >> >> >> > > >> >> > > >> >> > > >> >> > > -- >> >> > > *** >> >> > > Dr. A.D. Karve >> >> > > Trustee & Founder President, Appropriate Rural Technology Institute >> >> > > (ARTI) >> >> > >> >> > >> >> > >> >> > -- >> >> > *** >> >> > Dr. A.D. Karve >> >> > Trustee & Founder President, Appropriate Rural Technology Institute >> >> > (ARTI) >> >> > >> >> > _______________________________________________ >> >> > Gasification mailing list >> >> > >> >> > to Send a Message to the list, use the email address >> >> > [email protected] >> >> > >> >> > to UNSUBSCRIBE or Change your List Settings use the web page >> >> > >> >> > >> >> > http://lists.bioenergylists.org/mailman/listinfo/gasification_lists.bioenergylists.org >> >> > >> >> > for more Gasifiers, News and Information see our web site: >> >> > http://gasifiers.bioenergylists.org/ >> >> >> >> _______________________________________________ >> >> Gasification mailing list >> >> >> >> to Send a Message to the list, use the email address >> >> [email protected] >> >> >> >> to UNSUBSCRIBE or Change your List Settings use the web page >> >> >> >> >> >> http://lists.bioenergylists.org/mailman/listinfo/gasification_lists.bioenergylists.org >> >> >> >> for more Gasifiers, News and Information see our web site: >> >> http://gasifiers.bioenergylists.org/ >> >> >> > >> > >> > _______________________________________________ >> > Gasification mailing list >> > >> > to Send a Message to the list, use the email address >> > [email protected] >> > >> > to UNSUBSCRIBE or Change your List Settings use the web page >> > >> > http://lists.bioenergylists.org/mailman/listinfo/gasification_lists.bioenergylists.org >> > >> > for more Gasifiers, News and Information see our web site: >> > http://gasifiers.bioenergylists.org/ >> > >> >> >> >> -- >> *** >> Dr. A.D. Karve >> Trustee & Founder President, Appropriate Rural Technology Institute (ARTI) >> >> _______________________________________________ >> Gasification mailing list >> >> to Send a Message to the list, use the email address >> [email protected] >> >> to UNSUBSCRIBE or Change your List Settings use the web page >> >> http://lists.bioenergylists.org/mailman/listinfo/gasification_lists.bioenergylists.org >> >> for more Gasifiers, News and Information see our web site: >> http://gasifiers.bioenergylists.org/ > > _______________________________________________ > Gasification mailing list > > to Send a Message to the list, use the email address > [email protected] > > to UNSUBSCRIBE or Change your List Settings use the web page > http://lists.bioenergylists.org/mailman/listinfo/gasification_lists.bioenergylists.org > > for more Gasifiers, News and Information see our web site: > http://gasifiers.bioenergylists.org/ > -- *** Dr. A.D. Karve Trustee & Founder President, Appropriate Rural Technology Institute (ARTI) _______________________________________________ Gasification mailing list to Send a Message to the list, use the email address [email protected] to UNSUBSCRIBE or Change your List Settings use the web page http://lists.bioenergylists.org/mailman/listinfo/gasification_lists.bioenerg ylists.org for more Gasifiers, News and Information see our web site: http://gasifiers.bioenergylists.org/
_______________________________________________ Gasification mailing list to Send a Message to the list, use the email address [email protected] to UNSUBSCRIBE or Change your List Settings use the web page http://lists.bioenergylists.org/mailman/listinfo/gasification_lists.bioenergylists.org for more Gasifiers, News and Information see our web site: http://gasifiers.bioenergylists.org/
