Did you test the voltage of the individual cell banks in the module with the diodes out?
Brian Mehalic NABCEP Certified Solar PV Installation Professional™ R031508-59 520.204.6639 Solar Energy International http://www.solarenergy.org SEI Professional Services http://www.seisolarpros.com On Thu, Jul 6, 2017 at 6:18 PM, Taiyoko Sadewic < [email protected]> wrote: > Hi Brian, > Thanks for the info. Yes I tested the diode properly. I was concerned > that I needed to test the diode under a load to get a valid test. > > Taiyoko > > On Thu, Jul 6, 2017 at 4:14 PM, Brian Mehalic <[email protected]> > wrote: > >> Did you use the Diode Test function on the meter? If the diode is good >> you should see around 0.4-0.8 V in the forward bias, and OL in reverse. If >> it is bad (open) you'll get OL in both directions, and if it is shorted >> closed you'll get the 0.4-0.8 V reading in both directions. >> >> Shorted closed would be the failure mode that would indicate an >> always-closed diode providing a permanent bypass path and thus a drop of >> 25% of voltage per bad diode (or set of paralleled diodes). (These have 4 >> diodes right?). >> >> >> >> >> Brian Mehalic >> NABCEP Certified Solar PV Installation Professional™ R031508-59 >> 520.204.6639 <(520)%20204-6639> >> >> Solar Energy International >> http://www.solarenergy.org >> >> SEI Professional Services >> http://www.seisolarpros.com >> >> >> On Thu, Jul 6, 2017 at 4:31 PM, Taiyoko Sadewic < >> [email protected]> wrote: >> >>> Hi Wrenches, >>> We were installing Sanyo HIT modules back in 2006-2007 and in 2014 we >>> had a rash of bad Sanyo modules. The modules had distinct voltages below >>> the good modules ie 50% or 75%. Sanyo at the time (now Panasonic) >>> indicated that it was a bad diodes from a lightning strike not covered by >>> warranty. >>> >>> I finally got around to checking that out. I identified the purportedly >>> bad diode in one module (four per module) that was performing at 75% and >>> removed it. The diode appears to be fine using an ohm meter. Is that a >>> valid test? >>> >>> Anyone else have similar findings or experiences with this? Could >>> lightning blow apart the tab ribbons inside of the module? >>> >>> Thanks >>> >>> -- >>> <http://www.PositiveEnergySolar.com> >>> Taiyoko Sadewic >>> Employee-Owner >>> NABCEP™PV Installation Professional >>> NABCEP™Technical Sales >>> 3209 Richards Lane | Santa Fe, NM 87507 >>> cell 505.570.0137 <505.699.9032> >>> [email protected] <[email protected]> >>> www.PositiveEnergySolar.com >>> <http://www.positiveenergysolar.com/> >>> <http://www.facebook.com/positiveenergysolar> >>> <https://twitter.com/PositiveESolar> >>> <https://plus.google.com/+Positiveenergysolar> >>> <https://www.youtube.com/user/PositiveEnergySolar> >>> <https://www.positiveenergysolar.com/blog/blog/> >>> <https://www.positiveenergysolar.com/contact/refer-a-friend/> >>> <https://www.bcorporation.net/community/sunpower-positive-energy-solar> >>> >>> <http://www.solarreviews.com/installers/positive-energy-solar-reviews/> >>> >>> _______________________________________________ >>> List sponsored by Redwood Alliance >>> >>> List Address: [email protected] >>> >>> Change listserver email address & settings: >>> http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org >>> >>> List-Archive: http://www.mail-archive.com/re >>> [email protected]/maillist.html >>> >>> List rules & etiquette: >>> www.re-wrenches.org/etiquette.htm >>> >>> Check out or update participant bios: >>> www.members.re-wrenches.org >>> >>> >>> >> >> _______________________________________________ >> List sponsored by Redwood Alliance >> >> List Address: [email protected] >> >> Change listserver email address & settings: >> http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org >> >> List-Archive: http://www.mail-archive.com/re >> [email protected]/maillist.html >> >> List rules & etiquette: >> www.re-wrenches.org/etiquette.htm >> >> Check out or update participant bios: >> www.members.re-wrenches.org >> >> >> > > > -- > <http://www.PositiveEnergySolar.com> > Taiyoko Sadewic > Chief Financial Officer | Employee-Owner > NABCEP™PV Installation Professional > NABCEP™Technical Sales > 3209 Richards Lane | Santa Fe, NM 87507 > cell 505.570.0137 <505.699.9032> > [email protected] <[email protected]> > www.PositiveEnergySolar.com > <http://www.positiveenergysolar.com/> > <http://www.facebook.com/positiveenergysolar> > <https://twitter.com/PositiveESolar> > <https://plus.google.com/+Positiveenergysolar> > <https://www.youtube.com/user/PositiveEnergySolar> > <https://www.positiveenergysolar.com/blog/blog/> > <https://www.positiveenergysolar.com/contact/refer-a-friend/> > <https://www.bcorporation.net/community/sunpower-positive-energy-solar> > <http://www.solarreviews.com/installers/positive-energy-solar-reviews/> > > _______________________________________________ > List sponsored by Redwood Alliance > > List Address: [email protected] > > Change listserver email address & settings: > http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org > > List-Archive: http://www.mail-archive.com/[email protected]. > org/maillist.html > > List rules & etiquette: > www.re-wrenches.org/etiquette.htm > > Check out or update participant bios: > www.members.re-wrenches.org > > >
_______________________________________________ List sponsored by Redwood Alliance List Address: [email protected] Change listserver email address & settings: http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org List-Archive: http://www.mail-archive.com/[email protected]/maillist.html List rules & etiquette: www.re-wrenches.org/etiquette.htm Check out or update participant bios: www.members.re-wrenches.org
