http://www.space.com/missionlaunches/050520_sts114_tanktest.html
Discovery's Second External Tank Test a Success, NASA Says
By Tariq Malik
Staff Writer
posted: 20 May 2005
ET
NASA once again fueled the space shuttle Discovery’s external tank for
Friday in a test to iron out sensor and valve glitches.
Over the course of 11 hours, shuttle workers pumped and drained more
than 500,000 gallons (1.9 million liters) of supercold propellant into
Discovery’s external tank, which stands upright with the rest of the
launch stack at Kennedy Space Center’s Pad 39B in Cape Canaveral, Florida.
Unlike an April 14 test, engineers detected no fuel gauge sensor
malfunctions during the fueling process, but did monitor an identical
pressure valve anomaly from the earlier run.
“We had just a perfect test as far as I’m concerned,” said William
Parsons, NASA’s shuttle program manager, during a post-test
teleconference. “[But] we still have a lot of data to look at.”
Ripe weather for launch
If Discovery’s STS-114 crew – NASA’s first shuttle astronauts to fly
since the 2003 Columbia disaster - had been aboard the orbiter,
conditions would have been ripe to launch them into space.
“It was a good day,” said Sandy Coleman, NASA’s external tank project
manager, during the teleconference. “We could have launched today.”
The humidity today allowed more ice to form on Discovery’s tank today
than in the previous test, but amounted to little more than frost,
shuttle officials said.
Concerns over the potential fatal danger posed by ice debris shaking off
the tank prompted shuttle engineers to devise a new heater to limit the
hazard.
Discovery and the STS-114 crew are set to launch no earlier than July 13
on mission to test new hardware and procedures expected enhance space
shuttle safety. Their spaceflight will also deliver vital consumables,
science equipment and other cargo to the International Space Station,
where the Discovery crew plans to perform no less than three space walks.
NASA’s space shuttle fleet has been grounded since Feb. 1, 2003, when
the Columbia broke apart during reentry, killing its crew. Investigators
later found that launch debris, which struck Columbia’s left wing during
liftoff, caused the accident.
Potential delay
Despite today’s test, Discovery will eventually fly with a completely
different external tank, one which already stands ready to accept the
orbiter at the massive 52-story Vehicle Assembly Building (VAB) just
over four miles away from the launch pad. The tank was original slated
for NASA’s follow-up mission to STS-114, STS-121 aboard Atlantis.
But there are no current plans to check that replacement tank as well by
pumping it full of the liquid oxygen and liquid hydrogen fuel Discovery
consumes during liftoff. NASA officials, however, could call for that
extra test after reviewing data from Friday’s activity.
“Right now, I don’t have a third tanking test in my plan,” Parsons said,
conceding that some shuttle officials believe such a test could be
warranted, but have agreed to look over the data from today’s test
first. “But I wouldn’t rule it out completely.”
NASA launch director Michael Lienbach said the addition of a third
tanking test could push Discovery up to a week into its current launch
window, which runs from July 13 to July 31. If shuttle engineers push
hard, however, they could accomplish the feat by the window’s opening,
he added.
Shuttle engineers will soon install the new heater to the expandable
bellows portion of a liquid oxygen feed line on Discovery’s replacement
fuel tank to prevent ice buildup.
Another concern revolving adequate clearance between Discovery’s new
orbital boom – which astronauts will use to scan the orbiter for damage
– and a vital communication antenna has been addressed, NASA officials
said, adding that the separation between the two devices is slim during
deployment.
“We’ve been aware of this and we have a way to ensure we deploy the
[boom],” Parsons said. “I don’t believe this is going to be a real big
problem, this is just an operational workaround.”
Getting the kinks out
Shuttle managers ordered Friday’s test to reexamine a set of four
sensors that monitor liquid hydrogen propellant levels inside
Discovery’s external tank to ensure main engine cutoff during launch.
The sensors make sure Discovery’s engine shut down before its fuel tank
runs completely dry, NASA officials said.
Launch restrictions require that all four sensors function properly
before liftoff, though two of the devices cut out in the April 14 test.
Since then, pad engineers have swapped out wiring and rechecked the
connections running between Discovery and its tank. The result,
apparently, was a fully function sensor suite during the second test
fueling.
“The main engine cutoff sensors worked perfectly,” Parsons said. “It
probably points to the fact that…some kind of connection wasn’t exactly
right.”
More to unravel
One concern not solved in the May 20 test revolved around a
pressurization valve at the very top of Discovery’s external tank. The
valve apparently cycled the exact number of times – 13- as it did during
the April 14 tanking test, which is just shy of breaching launch
restrictions for an actual space shot. In a normal launch, the valve
cycles between eight and nine times.
“We’ve got to understand it,” Coleman said of the glitch. “We don’t like
flying right on the edge.”
Coleman said one potential culprit is a defuser, a sort of mesh screen
that that sits at the very top of the hydrogen tank and disperses fuel
in a manner that prevents hot spots from developing on the tanks
aluminum skin. The defuser on Discovery’s tank is different from those
on all past external tanks and will eventually be swapped out with an
older version, she added.
Lienbach said that Discovery will begin to make the 4.2-mile
(6.7-kilometer) journey back to the VAB no earlier than May 24, after
any remaining hydrogen has boiled out of its external tank.
There, the 171,000-pound (77,564-kilogram) orbiter will be demated from
its launch stack and attached to its new one. The enter assembly should
once again reach the launch pad by mid-June, shuttle officials said.
--
Dishnut-P
================================================================
Operator of RadioFree Dishnuts - Producer of The Dishnut News
heard Saturdays at 10pm EST. on
RFD, W0KIE Satellite Radio Network AMC-7 Transponder 5 / 7.50Mhz
(4DTV W-7 973), WTND-LP 106.3, and many micro LPFM stations.
http://dishnuts.net
RFD Listen Links: http://dishnuts.net/#Listen
Show Archives: (Partly Up) http://dishnuts.net/archive/
Reply with a "Thank you" if you liked this post.
_______________________________________________
MEDIANEWS mailing list
medianews@twiar.org
To unsubscribe send an email to:
[EMAIL PROTECTED]
