I am not expert on cooling systems but your troubleshooting list seems correct to me. Although I would start with flushing the system correctly. I am pretty sure that if you have too much air in the system things are not going to work correctly. Checking for a radiator cap that works seems super simple and might solve the whole problem! finally, regarding the thermostat, it is used to turn on and off the fan for the radiator. So, although it is always a good a idea to check it works properly, in your last test, was the fan coming on? does the bike has a temperature gauge? if so, did the problem occurred too soon, or at a normal temperature?
Just some thoughts Javier. On Sun, Mar 23, 2014 at 11:31 AM, EGrider <[email protected]> wrote: > My Nighthawk is the least problematic of all my bikes. May I ask a > non-Nighthawk question? I'll write this as a numbered list to keep it short > and to the point. > > I've written before that I like V30 Magnas. I've been working on a $200 > wonder from craigslist on and off for the last 18 months to educate myself > and to have a running backup to "old faithful." > > 1. When I started the bike up periodically during the winter, I noticed > that it started to smoke off the engine after it got up to temperature. I > couldn't tell where it was coming from exactly, but it was off the back > cylinders under the battery, coolant tank, and second fuel tank. > 2. Now that the weather is nicer, I decided to get the thing on the road. > I noticed that the coolant reservoir was low, so I put in some antifreeze. > It dumped all over my garage floor. Apparently the smoke was from coolant > dripping onto my rear exhaust pipes from a leak in the tube. > 3. I ripped bike apart and changed the line from the radiator by the cap > to the bottom of the overflow tank. I took it off a third parts bike. > 4. As it was really hard to see where the level was on the overflow tank, > I ended up filling it past the top mark. > 5. I started it up. Since it no longer dripped coolant on the exhaust > pipes, it no longer smoked. That's good. > 6. When it got up to temperature, coolant gushed out the radiator cap, and > I shut the bike off. That's bad. > > Where do I go from here? I'm thinking I should troubleshoot in this order: > 1. Drain the coolant down to the correct level and restart bike > 2. Change the radiator cap for one that I know can take the pressure and > restart bike > 3. Put the thermostat in hot water and confirm that it opens. Replace if > it doesn't. > 4. Swap out the water pump with one from another parts bike I bought > > One thing that's missing from the above is "flush the cooling system," > because I'm not sure how to go about that. I do have the Clymer manual, and > it talks about pressure testing the cap and cooling system but not about > flushing it per se. I could drain the system and refill it, probably should > anyway with an old bike, but does that guarantee that the coolant > circulates when the bike gets hot? > > If you have been down this road with old bikes that you've resurrected and > have a minute, I'd appreciate any advice. > > -- > You received this message because you are subscribed to the Google Groups > "Nighthawk Motorcycle Lovers!" group. > To unsubscribe from this group and stop receiving emails from it, send an > email to [email protected]. > To post to this group, send email to [email protected]. > Visit this group at http://groups.google.com/group/nighthawk_lovers. > For more options, visit https://groups.google.com/d/optout. > -- You received this message because you are subscribed to the Google Groups "Nighthawk Motorcycle Lovers!" group. To unsubscribe from this group and stop receiving emails from it, send an email to [email protected]. To post to this group, send email to [email protected]. Visit this group at http://groups.google.com/group/nighthawk_lovers. For more options, visit https://groups.google.com/d/optout.
