Oh, and don't use regular automotive anti-freeze, it contains silica to act as an abrasive to keep the water passages clear. On an all aluminum cooling system like on a bike it just chews up the water pump. Sent via BlackBerry by AT&T
-----Original Message----- From: "Allen Thomas" <[email protected]> Date: Mon, 24 Mar 2014 11:18:10 To: Nightwawk Lovers<[email protected]> Reply-To: [email protected] Subject: Re: [Nighthawk Lovers] Non-Nighthawk cooling system question There is a procedure to "burp" the V4 engines. If you don't do it air will sit in the water pump and essentially you get no flow. The VFR list had this discussion last year. If I remember correctly you have to lean the bike over and squeeze one of the hoses off the water pump. I'll see if I can dig up the email, or you can search for Burp on the VFR-list google group. Sent via BlackBerry by AT&T -----Original Message----- From: EGrider <[email protected]> Sender: [email protected] Date: Sun, 23 Mar 2014 08:31:46 To: <[email protected]> Reply-To: [email protected] Subject: [Nighthawk Lovers] Non-Nighthawk cooling system question My Nighthawk is the least problematic of all my bikes. May I ask a non-Nighthawk question? I'll write this as a numbered list to keep it short and to the point. I've written before that I like V30 Magnas. I've been working on a $200 wonder from craigslist on and off for the last 18 months to educate myself and to have a running backup to "old faithful." 1. When I started the bike up periodically during the winter, I noticed that it started to smoke off the engine after it got up to temperature. I couldn't tell where it was coming from exactly, but it was off the back cylinders under the battery, coolant tank, and second fuel tank. 2. Now that the weather is nicer, I decided to get the thing on the road. I noticed that the coolant reservoir was low, so I put in some antifreeze. It dumped all over my garage floor. Apparently the smoke was from coolant dripping onto my rear exhaust pipes from a leak in the tube. 3. I ripped bike apart and changed the line from the radiator by the cap to the bottom of the overflow tank. I took it off a third parts bike. 4. As it was really hard to see where the level was on the overflow tank, I ended up filling it past the top mark. 5. I started it up. Since it no longer dripped coolant on the exhaust pipes, it no longer smoked. That's good. 6. When it got up to temperature, coolant gushed out the radiator cap, and I shut the bike off. That's bad. Where do I go from here? I'm thinking I should troubleshoot in this order: 1. Drain the coolant down to the correct level and restart bike 2. Change the radiator cap for one that I know can take the pressure and restart bike 3. Put the thermostat in hot water and confirm that it opens. Replace if it doesn't. 4. Swap out the water pump with one from another parts bike I bought One thing that's missing from the above is "flush the cooling system," because I'm not sure how to go about that. I do have the Clymer manual, and it talks about pressure testing the cap and cooling system but not about flushing it per se. I could drain the system and refill it, probably should anyway with an old bike, but does that guarantee that the coolant circulates when the bike gets hot? If you have been down this road with old bikes that you've resurrected and have a minute, I'd appreciate any advice. -- You received this message because you are subscribed to the Google Groups "Nighthawk Motorcycle Lovers!" group. To unsubscribe from this group and stop receiving emails from it, send an email to [email protected]. To post to this group, send email to [email protected]. Visit this group at http://groups.google.com/group/nighthawk_lovers. For more options, visit https://groups.google.com/d/optout. -- You received this message because you are subscribed to the Google Groups "Nighthawk Motorcycle Lovers!" group. To unsubscribe from this group and stop receiving emails from it, send an email to [email protected]. To post to this group, send email to [email protected]. Visit this group at http://groups.google.com/group/nighthawk_lovers. For more options, visit https://groups.google.com/d/optout.
