Sounds like: A) the batteries are getting old, and are not paralleled properly. B) The desulphators aren't that great. I have some pics of one that completely short circuited, melted, and caught on fire. I would never put those in, myself. C) I no longer recommend monthly EQing, but I think its a good idea when either the bank has not reached full charge for several weeks, or battery voltages, string currents, or specific gravity readings indicate EQing is necessary. New controllers with temp compensation, PWM, and 3 stage charging take much better care of the batteries. Monthly EQing IMHO is a relic from the C30 days, and now results in unnecessary over heating and over watering.
Are these perhaps a Rolls L 16? R. Walters [email protected] Solar Engineer On Feb 13, 2010, at 10:14 AM, [email protected] wrote: > Dan, > You are on the right track. I've been off the Desulphators for years because > I had so many systems without them that were lasting years longer than > predicted between battery swap outs. I don't know about refractometer vs > hydrometer. I use and trust a "glass in glass" hydrometer. > > Are these bats Trojan L-16's? > 4 strings of L-16's @ 48v seems like (32) bats. Is that correct. That doesn't > sound right. > > In general. Battery Charge rates of between C-10 to C-20 for PV. And with an > engine generator C-8 to C-12. Limit parallel strings to two (three at most in > rare cases). All battery charging needs good control, proper settings, > temperature comp, and somebody who understands how it all works to teach the > homeowner and be there to answer questions. > > We teach the proper use of the hydrometer as a tool that confirms actual > battery condition. We strongly recommend that batteries are fully recharged > at least every week to ten days. Fully recharged means (for me) that the > voltage has gotten up to 59 volts (48v system) and stayed there for a minimum > of two hours (confirm effectiveness of time and battery charge level with > TriMetric meter amp function here, should have tapered down below 12 amps on > a typical 48v battery bank with voltage still at absorb level (59), can > confirm more definitively with a hydrometer here). Of course individual > systems, and battery types, vary. Properly programmed, and understood, > TriMetric monitoring is very useful here. Use hydrometer to check on how this > is all working out for the system. Frequency of hydrometer use varies with > owner's experience level and system age. Check for all cells to be charged > and within 15 basis points, highest to lowest, to be confirmed as fully > charged. > > I find that a TriMetric monitor helps with the teaching and troubleshooting > process. Different end users understand it and learn how to use it with > varying degrees of success. Helps in a high percentage of our off-grid > systems. > > > Sent via BlackBerry by AT&T > > -----Original Message----- > From: [email protected] > Date: Sat, 13 Feb 2010 06:04:03 > To: RE-wrenches<[email protected]> > Subject: [RE-wrenches] Refractometer vs Hydrometer? > > _______________________________________________ > List sponsored by Home Power magazine > > List Address: [email protected] > > Options & settings: > http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org > > List-Archive: > http://lists.re-wrenches.org/pipermail/re-wrenches-re-wrenches.org > > List rules & etiquette: > www.re-wrenches.org/etiquette.htm > > Check out participant bios: > www.members.re-wrenches.org > > > _______________________________________________ > List sponsored by Home Power magazine > > List Address: [email protected] > > Options & settings: > http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org > > List-Archive: > http://lists.re-wrenches.org/pipermail/re-wrenches-re-wrenches.org > > List rules & etiquette: > www.re-wrenches.org/etiquette.htm > > Check out participant bios: > www.members.re-wrenches.org > > _______________________________________________ List sponsored by Home Power magazine List Address: [email protected] Options & settings: http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org List-Archive: http://lists.re-wrenches.org/pipermail/re-wrenches-re-wrenches.org List rules & etiquette: www.re-wrenches.org/etiquette.htm Check out participant bios: www.members.re-wrenches.org
