I can confirm that quite a bit of water builds up inside the pipe. A few times on rewiring old systems, we used self tapping screws to attach conduit and combiner boxes to the existing pole, and we've had water start running out the hole when it was close to the ground. This was in a dry climate (New Mexico) This was with a rack that didn't cap the pole, but I was still surprised how much water was in there. (gallons) Filling with concrete does seem to be a good idea, but I'll point out its not as easy as it sounds. The concrete just pours out the bottom into the footing, as you keep filling it from the top. Pouring in a foot of gravel in the bottom first would help, or filling the pipe after the footing dried some would do it too.
No free lunch, R. Walters [email protected] Solar Engineer On Jul 26, 2011, at 2:08 PM, Dave Palumbo wrote: > Roy, > > I have heard that the small amount of water from condensation will be > absorbed by the concrete itself. Don't know for an absolute fact that this is > true though. > > Dave > > -----Original Message----- > From: [email protected] > [mailto:[email protected]] On Behalf Of Roy Rakobitsch > Sent: Tuesday, July 26, 2011 3:17 PM > To: RE-wrenches > Subject: Re: [RE-wrenches] pole mounts > > I would think that adding concrete partially up the pole would cause water > and condensation to collect near the bottom and not drain properly. This > could possibly lead to freezing and the pipe being blown out or damaged, > even if the top is completely capped. I would think that you should either > completely fill the pipe, or leave it empty with a good layer of gravel at > the bottom to allow it to drain properly. I also have no studies to back > this up, but it was just a thought. > > Roy Rakobitsch > NABCEP Certified Small Wind Installer® > NABCEP Certified Solar PV Installer® > NYSERDA eligible Small Wind installer > Wind/PV Design Engineer > Windsine Inc. > 631-514-4166 > www.windsine.org > > On Tue, July 26, 2011 3:05 pm, Dave Palumbo wrote: >> Todd, >> >> >> >> We add concrete inside of our steel pipe masts, up to grade level, in the >> interest of having more weight below ground level. I wouldn’t say that >> it made the pipe stronger (that better be strong enough as is) but more >> weight down low will help keep it rooted in a big wind event. >> >> >> >> Dave >> >> >> >> From: [email protected] >> [mailto:[email protected]] On Behalf Of >> [email protected] >> Sent: Tuesday, July 26, 2011 2:50 PM >> To: RE-wrenches >> Subject: [RE-wrenches] pole mounts >> >> >> >> Wrenches, >> >> >> >> Fact or fiction: Adding concrete to the inside of a pole mount pipe makes >> it stronger. >> >> >> >> Thanks, >> >> >> >> Todd >> >> >> >> >> Sent from Finest Planet WebMail. >> >> _______________________________________________ >> List sponsored by Home Power magazine >> >> List Address: [email protected] >> >> Options & settings: >> http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org >> >> List-Archive: >> http://lists.re-wrenches.org/pipermail/re-wrenches-re-wrenches.org >> >> List rules & etiquette: >> www.re-wrenches.org/etiquette.htm >> >> Check out participant bios: >> www.members.re-wrenches.org >> >> > > > > > > > _______________________________________________ > List sponsored by Home Power magazine > > List Address: [email protected] > > Options & settings: > http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org > > List-Archive: > http://lists.re-wrenches.org/pipermail/re-wrenches-re-wrenches.org > > List rules & etiquette: > www.re-wrenches.org/etiquette.htm > > Check out participant bios: > www.members.re-wrenches.org > > _______________________________________________ > List sponsored by Home Power magazine > > List Address: [email protected] > > Options & settings: > http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org > > List-Archive: > http://lists.re-wrenches.org/pipermail/re-wrenches-re-wrenches.org > > List rules & etiquette: > www.re-wrenches.org/etiquette.htm > > Check out participant bios: > www.members.re-wrenches.org > _______________________________________________ List sponsored by Home Power magazine List Address: [email protected] Options & settings: http://lists.re-wrenches.org/options.cgi/re-wrenches-re-wrenches.org List-Archive: http://lists.re-wrenches.org/pipermail/re-wrenches-re-wrenches.org List rules & etiquette: www.re-wrenches.org/etiquette.htm Check out participant bios: www.members.re-wrenches.org
