Hello. I think that both the FFA content and water content are too high in that oil. The water content is the worst enemy for a good trans-etherification. Try this : Put the oil in a vessel at 70oC for 24 hrs. The water may form a separate phase at the bottom of the vessel. Check the water content. ExxonMobile sells a nice kit called Mobil water test. The active chemical compound in this is calciumdihydride. It is a reliable method. Do not try to transesterify again until the water content is around 0,5%. And- watch out for any remaining detergents in the oil ! Jan Warnqvist AGERATEC AB
[EMAIL PROTECTED] + 46 554 201 89 +46 70 499 38 45 ----- Original Message ----- From: "Appal Energy" <[EMAIL PROTECTED]> To: <[EMAIL PROTECTED]> Sent: Sunday, March 06, 2005 1:25 AM Subject: Re: [Biofuel] A problem with WVO > Kitch, > > > Any suggestions ? > > Conduct a series of bracket titrations and/or move towards the acid/base > process. > > Todd Swearingen > > ----- Original Message ----- > From: <[EMAIL PROTECTED]> > To: <[EMAIL PROTECTED]> > Sent: Saturday, March 05, 2005 9:54 AM > Subject: [Biofuel] A problem with WVO > > > > Hello brothers and sisters. > > > > I have been making my own bio for about three years and have been very > > successful with it. I HAVE had some great failures such as filter clogging > > raw > > fat in the fuel, gertting it in the tank while some Glycerine was still > > separating - MORE clogged filters, but have learned so much that i now > > give > > free seminars and have about 50 people now brewing their own. > > > > So my problem is this: I have a restaurant that gives me about 20 gallons > > a > > week of Canola oil that they have cooked french fries and hot dogs in. > > Never > > too dirty, but quite dark. > > > > I have had BAD results with this stuff. I titrate and it always needs to > > have > > an excessive amount of lye added and when I do, I get a solid MESS. I have > > even tried to make various half litre batches with the same results - an > > almost solid block of GLOP. Now, i have added perhaps uip to 20% of this > > oil > > in with my more common crappy soy oil and THEN it works OK. > > > > Any suggestions ? > > > > Kitch in Az > > > > 99 Golf diesel > > 82 Vanny camper diesel > > 82 Vanny diesel "grease getter" > > > > Small diesels driving truck alternators backing up solar power > > _______________________________________________ > Biofuel mailing list > [EMAIL PROTECTED] > http://wwia.org/mailman/listinfo.cgi/biofuel > > Biofuel at Journey to Forever: > http://journeytoforever.org/biofuel.html > > Biofuel archives at Infoarchive.net (searchable): > http://infoarchive.net/sgroup/biofuel/ > _______________________________________________ Biofuel mailing list [EMAIL PROTECTED] http://wwia.org/mailman/listinfo.cgi/biofuel Biofuel at Journey to Forever: http://journeytoforever.org/biofuel.html Biofuel archives at Infoarchive.net (searchable): http://infoarchive.net/sgroup/biofuel/