If it was the regulator sending in too much current... wouldn't that 30amp fuse have blown before the plug melted?
On Fri, 22 Feb 2019, 3:43 PM Darin Hatton, <[email protected]> wrote: > It's all good, I know what you meant. > > On Fri, Feb 22, 2019, 3:28 PM 'Pike' via Nighthawk Motorcycle Lovers! < > [email protected]> wrote: > >> Sorry,true,got turned around. >> >> On Feb 22, 2019, at 2:15 PM, Darin Hatton <[email protected]> wrote: >> >> The black finned object below left side cover >> >> On Fri, Feb 22, 2019, 3:12 PM Darin Hatton <[email protected]> >> wrote: >> >>> Should be left side as this is determined as the rider sits on bike >>> >>> On Fri, Feb 22, 2019, 3:10 PM 'Pike' via Nighthawk Motorcycle Lovers! < >>> [email protected]> wrote: >>> >>>> On my 84 700s the regulator is under the right side plastic panel that >>>> says nighthawk s. >>>> >>>> On Feb 22, 2019, at 2:05 PM, Final Twist < >>>> [email protected]> wrote: >>>> >>>> Thanks.... wires should be same. odds of the same bad connection >>>> being the issue is low since I had replaced both the solenoid and the >>>> connector plug. I figured it's the voltage regulator perhaps. ordered a >>>> new one just for good measure. >>>> >>>> By the way, could someone please advise on where the voltage regulator >>>> is? Under the tank? >>>> >>>> On Fri, 22 Feb 2019, 2:58 PM Darin Hatton, <[email protected]> >>>> wrote: >>>> >>>>> Follow kyles installation tips. If your bike is wired same as my 700s >>>>> the other wires go to clutch switch, kill switch,and regulator/rectifier. >>>>> If I were you I'd rewire new plug and check voltage on wire going to >>>>> regulator /rectifier. On my 700s nighthawk that wire is white. Shouldn't >>>>> be over 15 volts dc or so rev'd up. This wire puts the charge into the >>>>> battery as you ride. Of course you'll need a multi meter to check. If >>>>> your >>>>> reading is high your regulator /rectifier may be on its way out. Hopefully >>>>> the meltdown was from loose connection / high resistance. Those plugs >>>>> should be a pain in the ass to plug in and unplug >>>>> >>>>> On Fri, Feb 22, 2019, 11:14 AM Holger Selover-Stephan < >>>>> [email protected]> wrote: >>>>> >>>>>> I’m new around here as well, but from other vehicles, if electrical >>>>>> insulation melts, it usually means there is a short right where the >>>>>> damage >>>>>> is found. If you had an issue elsewhere in the system that causes >>>>>> over-current, you’d either have a fuse pop or you’d see melting >>>>>> elsewhere. >>>>>> You found melting at the same spot twice, so that’s where your cause is, >>>>>> nowhere else. It’s most likely crud, stray strands, or exposed wires that >>>>>> are moved together, that shortens the circuit right there, which creates >>>>>> the heat that damaged the wires or connector. >>>>>> >>>>>> Holger >>>>>> >>>>>> > On Feb 22, 2019, at 6:48 AM, Final Twist < >>>>>> [email protected]> wrote: >>>>>> > >>>>>> > Are bad connections the only possible cause of this happening? >>>>>> Does anyone know what the other 3 wires do in the connector? I can't >>>>>> read >>>>>> the really complex wiring diagrams for the motorcycle >>>>>> >>>>>> -- >>>>>> You received this message because you are subscribed to the Google >>>>>> Groups "Nighthawk Motorcycle Lovers!" group. >>>>>> To unsubscribe from this group and stop receiving emails from it, >>>>>> send an email to [email protected]. >>>>>> To post to this group, send email to >>>>>> [email protected]. >>>>>> Visit this group at https://groups.google.com/group/nighthawk_lovers. >>>>>> For more options, visit https://groups.google.com/d/optout. >>>>>> >>>>> -- >>>>> You received this message because you are subscribed to a topic in the >>>>> Google Groups "Nighthawk Motorcycle Lovers!" group. >>>>> To unsubscribe from this topic, visit >>>>> https://groups.google.com/d/topic/nighthawk_lovers/Kk25hVmHSH4/unsubscribe >>>>> . >>>>> To unsubscribe from this group and all its topics, send an email to >>>>> [email protected]. >>>>> To post to this group, send email to [email protected] >>>>> . >>>>> Visit this group at https://groups.google.com/group/nighthawk_lovers. >>>>> For more options, visit https://groups.google.com/d/optout. >>>>> >>>> -- >>>> You received this message because you are subscribed to the Google >>>> Groups "Nighthawk Motorcycle Lovers!" group. >>>> To unsubscribe from this group and stop receiving emails from it, send >>>> an email to [email protected]. >>>> To post to this group, send email to [email protected]. >>>> Visit this group at https://groups.google.com/group/nighthawk_lovers. >>>> For more options, visit https://groups.google.com/d/optout. >>>> >>>> -- >>>> You received this message because you are subscribed to the Google >>>> Groups "Nighthawk Motorcycle Lovers!" group. >>>> To unsubscribe from this group and stop receiving emails from it, send >>>> an email to [email protected]. >>>> To post to this group, send email to [email protected]. >>>> Visit this group at https://groups.google.com/group/nighthawk_lovers. >>>> For more options, visit https://groups.google.com/d/optout. >>>> >>> -- >> You received this message because you are subscribed to the Google Groups >> "Nighthawk Motorcycle Lovers!" group. >> To unsubscribe from this group and stop receiving emails from it, send an >> email to [email protected]. >> To post to this group, send email to [email protected]. >> Visit this group at https://groups.google.com/group/nighthawk_lovers. >> For more options, visit https://groups.google.com/d/optout. >> >> <20190222_151411.jpg> >> >> -- >> You received this message because you are subscribed to the Google Groups >> "Nighthawk Motorcycle Lovers!" group. >> To unsubscribe from this group and stop receiving emails from it, send an >> email to [email protected]. >> To post to this group, send email to [email protected]. >> Visit this group at https://groups.google.com/group/nighthawk_lovers. >> For more options, visit https://groups.google.com/d/optout. >> > -- > You received this message because you are subscribed to a topic in the > Google Groups "Nighthawk Motorcycle Lovers!" group. > To unsubscribe from this topic, visit > https://groups.google.com/d/topic/nighthawk_lovers/Kk25hVmHSH4/unsubscribe > . > To unsubscribe from this group and all its topics, send an email to > [email protected]. > To post to this group, send email to [email protected]. > Visit this group at https://groups.google.com/group/nighthawk_lovers. > For more options, visit https://groups.google.com/d/optout. > -- You received this message because you are subscribed to the Google Groups "Nighthawk Motorcycle Lovers!" group. To unsubscribe from this group and stop receiving emails from it, send an email to [email protected]. To post to this group, send email to [email protected]. Visit this group at https://groups.google.com/group/nighthawk_lovers. For more options, visit https://groups.google.com/d/optout.
