Wrenches, In late 2003 we installed a 24V set of Rolls-Surrette 4-KS-21PS 6V 1104 A/hr batteries in the off-grid system of a long-time client. The client's system had a democracy array of around 800 watts of tracked PV. In early 2005 we added 1,280 watts of additional PV, and the client hasn't run the generator since; the system rarely drops below 80% and fills to 100% most days in sunny New Mexico. Batteries are located in a basement, so temperatures stay relatively constant, although it will vary slightly seasonally. MX60 controller is temperature compensated, with 29.6 VDC bulk and 31.4 VDC EQ set points.
The problem is that the client reports being unable to achieve previous EQ voltages, and this inability appears to be a new development. The system is otherwise performing well. As the client is sharp and pays close attention to the system's operation, I'm not ready to blame user ignorance (with one possible exception; read on). This may be an issue of seasonally warm temperatures, but I'm not sure this would explain the full 0.4 VDC reduction in voltage. I told him that I would post his problem to this list, and also request advice from Surrette Battery. Here is the client's description of the symptoms: I'm concerned that I am unable to equalize batteries at this time. Up until June of this year the Tri-Metric readings during equalizing indicated holding voltage at 31.1, with maximum amps gain of around 52. Three weeks ago, when set on equalize, the maximum voltage reading was 30.7, with maximum amps of 46; this was reached around noon, and by around 1:30 pm voltage/amps began its typical afternoon drop-off. I attempted equalizing on two other occasions since then--the last time this past Saturday, with clear skies up until mid-afternoon--but having the same results. So, the question is: are my batteries beginning their decline? We've had this set for 4 1/2 years, so it would seem a bit too early for this, given that these batteries are expected to last 7-10 years. Second issue, possibly related: On another matter, I have been using deionized water for the batteries for as long as we've been using photovoltaics (since 1991), as it is my understanding that deioinized water is virtually the same as distilled water--I just checked Wikipedia on this (using "deionized and distilled water" as the search phrase), and this appears to be the case. I don't know the answer to this question, as we have always recommended distilled water only in batteries, and have never faced this question. Any help would be appreciated. Allan Sindelar allan_(at)_positiveenergysolar.com <mailto:[EMAIL PROTECTED]> NABCEP certified solar PV installer Positive Energy, Inc. 3225A Richards Lane Santa Fe NM 87507 505 424-1112 Allan Sindelar allan_(at)_positiveenergysolar.com <mailto:[EMAIL PROTECTED]> NABCEP certified solar PV installer Positive Energy, Inc. 3225A Richards Lane Santa Fe NM 87507 505 424-1112
_______________________________________________ List sponsored by Home Power magazine [email protected] http://lists.re-wrenches.org/listinfo.cgi/re-wrenches-re-wrenches.org List rules & etiquette: http://www.re-wrenches.org/etiquette.htm Check out participant bios: www.members.re-wrenches.org
