yes, you want to do the k1 deal, There used to be a writeup before
mbz.org crashed but not sure if its still around.
Tim C wrote:
Hello M-B folks,
My name is Tim Clark and I have recently acquired an 83 300SD. I have a
question on it and a fellow Rennlister (a glance at my email will reveal my
other automotive "prior commitment" - all 10 of my allotted email addresses
are in use for the time being, so this will have to suffice) referred me
here, which is excellent as I found the Benzworld forums to be not quite as
useful as I had hoped. Mr. Dave Gilmore (said R'lister) already replied
with one take on my question, but I'd now like to cut/paste said question
here and see what additional insights are generated.
Original question, slightly edited for this presentation:
I recently purchased an 83 300SD, approx 260k miles. Transmission slips on
2-3 shift - but all other shifts are solid and positive, both up and down -
and the 3-2 (edit - corrected from "4-3" which isn't the shift in question,
oops) downshift is also solid. My question is, if only the one shift is bad,
is this likely to be an adjustment issue? I would expect if clutch pack
wear was involved, other shifts would be off too - in other words, how
likely is it that one clutch pack is toast while the others are totally fine
(my impression is there are separate clutch packs for each gear - this is my
first auto-trans car in quite awhile so please forgive ignorance there)? The
car came with sporadic records (well-documented for a few years at a time,
then nothing for a while), so I'm not sure if anything has been done to the
tranny - another question is, how long should these go before some service
is required - how likely is it that the tranny may have already received
attention at some point? Finally, if anyone can shed light on how auto
transmissions work/what can be adjusted (pre-electronic trannies that is),
I'd appreciate it much.
Here's Dave's reply to avoid duplication of info:
"Mine does this too when cold. I have read a K-1 spring kit solves the
problem and it can be installed while the trans is in the car. Rusty at
www.buymbparts.com/ or 800-741-5252 likely can provide it. When I first
got my car I changed to Mobile 1 ATF and that almost cured it. I plan to
try the K-1 deal next. Mine has 75,000 on it.
I have read the transmission in these cars usually last about 200,000 miles
before a rebuild, although some people get more. The adjustment procedure
is complicated because of the vacuum interaction. I suggest a fluid &
filter change along with careful adjustment to the MB specs before doing
anything radical. The adjustment does alter the firmness of all the
shifts. That is why I am suspecting the K-1 in our cases."
Oh, and I checked the records I have - the tranny fluid was changed about 7k
miles ago, but no filter - I assume this is just like changing the oil
without changing the filter - basically pointless? So might be a good place
to start....
Thanks in advance,
Tim
88 944 (reasonably good shape, needs a few things)
83 300SD (needs paint on roof, missing a/c, pretty much everything works,
runs strongly)
_______________________________________
http://www.striplin.net
For new parts see official list sponsor: http://www.buymbparts.com/
For used parts email [EMAIL PROTECTED]
To Unsubscribe or change delivery options go to:
http://striplin.net/mailman/listinfo/mercedes_striplin.net
--
Kaleb C. Striplin/Claremore, OK
89 560SEL, 87 300SDL, 85 380SE, 85 300D,
84 250 LWB, 83 300TD, 81 300TD, 81 240D, 81 240D,
76 450SEL, 76 240D, 76 300D, 74 240D, 69 250
http://www.striplin.net